MAGNAFLUX CORPORATION -- SKC-NF/ZC-7B CLEANER/REMOVER -- 6850-00-585-6426 
=====================  Product Identification  =====================

Product ID:SKC-NF/ZC-7B CLEANER/REMOVER
MSDS Date:06/14/1988
FSC:6850
NIIN:00-585-6426
=== Responsible Party ===
Company Name:MAGNAFLUX CORPORATION
Address:7300 WEST LAWRENCE AVENUE
City:CHICAGO
State:IL
ZIP:60656-3504
Country:US
Info Phone Num:312-867-8000
Emergency Phone Num:312-867-8000
Preparer's Name:MR.BRUCE C.GRAHAM
CAGE:37676
=== Contractor Identification ===
Company Name:ILLINOIS TOOL WORKS INC MAGNAFLUX DIV
Address:3624 WEST LAKE AVENUE
Box:City:GLENVIEW
State:IL
ZIP:60025
Country:US
Phone:847-657-5300/
CAGE:37676

=============  Composition/Information on Ingredients  =============

Ingred Name:METHYL CHLOROFORM (1,1,1-TRICHLOROETHANE)  (SARA III)
CAS:71-55-6
RTECS #:KJ2975000
Fraction by Wt: 100.0%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:350 PPM
ACGIH TLV:350 PPM/450STEL;9394
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS
Ozone Depleting Chemical:1

Ingred Name:1,4-DIOXANE (DIETHYLENE DIOXIDE)  (SARA III)
CAS:123-91-1
RTECS #:JG8225000
Fraction by Wt: 1.0%
OSHA PEL:S, 100 PPM
ACGIH TLV:S, 25 PPM; 9293
EPA Rpt Qty:100 LBS
DOT Rpt Qty:100 LBS

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE:  INHALATION-DIZZINESS,
    DROWSINESS, NAUSEA; SKIN:  IRITANT, EYES:  IRRITATION.  CHRONIC:
    DERMATITIS.
Explanation of Carcinogenicity:1,1,1-TRICHLOROETHANE AND 1,4-DIOXANE
    ARE UNDER TEST TO DETERMINE THE POSSIBLE CARCINOGENICITY.OSHA TLV
    LOWER THAN ACGIH
Effects of Overexposure:INHALATION:CAUSES
    DIZZINESS,DROWSINESS,NAUSEA.CAUSES UNCONSCIOUSNESS AT HIGH
    EXPOSURE; SKIN:NOT ABSORBED THROUGH SKIN IN SIGNIFICANT
    AMOUNTS.HOWEVER,IRRITATES BY DISSOLVING SKIN OILS; EYES:IRRITATING 
    DUE TO STRONG SOLVENT ACTION; INGESTION:LOW SINGLE DOSE TOXICITY IN
    TEST ANIMALS.
Medical Cond Aggravated by Exposure:NONE KNOWN TO MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:INHALATION:REMOVE TO FRESH AIR.IF NOT BREATHING,GIVE CPR.IF
    BREATHING IS DIFFICULT,GIVE OXYGEN; SKIN:WASH OFF IN FLOWING WATER
    OR SHOWER.RMV CONTAMINATED CLOTHING AND WASH BEFORE REUSE.USE
    SOOTHING LO TION; EYES:FLUSH EYES WITH A STEADY,GENTLE FLOW OF
    WATER.GET MEDICAL ASST; INGESTION:DO NOT INDUCE VOMITING.IF VOMIT
    IS INHALED,IT MAY CAUSE ASPHYXIATION.GET MED ATTN IMMEDIATELY; IN
    EMERGENCY CALL MD

=====================  Fire Fighting Measures  =====================

Flash Point:NONE
Lower Limits:10.0%
Upper Limits:15.0%
Extinguishing Media:EXTINGUISH WITH AGENT SUITABLE FOR SURROUNDING FIRE
Fire Fighting Procedures:USE H*20 TO COOL EXPD CONTRS. USE SCBA & FULL
    PROT.CLTHG.
Unusual Fire/Explosion Hazard:VAP PARTIALLY DECOMPOSE TO TOXIC GASES
    WHEN EXPOSED TO FLAME,ARCS OR RED HOT SURFACES.

==================  Accidental Release Measures  ==================

Spill Release Procedures:SM QTY(LESS THAN QUART):WIPE UP W/RAGS BUT DO
    NOT BREATHE VAPORS.PLACE RAGS IN CLOSED DRUM;LG QTY(MORE THAN
    QUART):EVACUATE UNPROTECTED PERSONS.ELIMINATE IGNITION SOURCES.WEAR
    PERSONAL SAFETY EQUIP.DI KE AREA.ABSORB W/ABSORBENT.PLACE WASTE IN
    COVRD DR

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AWAY FROM HEAT SOURCES TO
    MINIMIZE THE DANGER FROM EXPOSURE TO FIRES.STORE IN DRY,COOL,WELL
    VENTILATED AREA.
Other Precautions:DO NOT USE AROUND FLAMES/RED HOT SURFACES.DO NOT HEAT
    ABOVE 130F.AVOID FREQUENT/PROLONGED EXPOSURE TO SKIN.AVOID
    BREATHING VAPORS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:IF USED IN CONFINED AREA MASK WITH SEPARATE AIR
    SUPPLY
Ventilation:LOCAL EXHAUST PREFERRED TO CONTROL TLV IN AIR
Protective Gloves:RUBBER
Eye Protection:SAFETY GOGGLES
Other Protective Equipment:FULL WORK CLOTHING TO PREVENT REPEATED OR
    PROLONGED CONTACT.
Supplemental Safety and Health
SKC-NF/ZC-7B CLEANER IS CLASS (1) CLEANR OF MIL-I-25135,REVISION D
    I/A/W QPL-25135-15; THE SAME CLEANER USED TO BE GROUP IA/VII OF
    MIL-I-25135,REV C & QPL-25135-13.

==================  Physical/Chemical Properties  ==================

HCC:T4
Boiling Pt:B.P. Text:162F/72C
Vapor Pres:230
Vapor Density:4
Spec Gravity:1.3
Evaporation Rate & Reference:3.0 (ETHYL ALCOHOL = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, COLORLESS, MOBILE LIQUID, FAINT ODOR.
Percent Volatiles by Volume:100

=================  Stability and Reactivity Data  =================

WILL SOFTEN MANY PLASTICS & COATINGS,ALUMINUM,ALUMINUM ALLOY
Stability Condition to Avoid:RED HOT SURFACES,OPEN FLAME,ARCS.
Hazardous Decomposition Products:PHOSGENE,HYDROCHLORIC ACID GAS, &
    CHLORINE GAS.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF AS EPA HAZARDOUS WASTE #F002;LIQUID
    MAY BE SENT TO SOLVENT RECLAIMER.DISPOSE OF IN FULL COMPLIANCE OF
    FEDERAL,STATE,AND LOCAL REGULATORY STATUTES.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.